Notorious Landfill Gas Explosions During the 1980s in the UK and the US

Landfill gas explosionsLandfill gas explosions taught the UK waste management industry of the very real dangers of methane gas through hard experience. The industry learnt from a series of accidents, some of which are described below, plus a disaster in the water industry. That disaster was the Abbeystead Disaster which was caused by a methane explosion in a large diameter water pumping main

Sadly, there were penalties in terms of death and injury when the first landfill gas explosions occurred.

Parallel Experiences Should Have Acted as a Warning…

There were parallel experiences in the mining industry from many years before, which could have from the start warned, the landfill operators to take precautions.

Despite those earlier experiences, it took several explosions before the landfill operators and environmental regulators took action on safety.

In hindsight, it is surprising that earlier action was not taken to prevent these landfill gas explosions. It had been within living memory when the  terrible death-toll from the UK water industry’s Abbeystead Explosion occurred in the 1970s. Those deaths had been extensively reported in the UK press.

When UK landfills got larger and started to make landfill gas (50% to 60% methane) in the late 1970s, there was already a memory of that disaster.

The methane explosion risk should have been already well-known.

Thankfully, with current greatly improved landfill practices, landfill gas explosion accidents of the type described here, have become a thing of the past in the UK.

We describe below some of the most notorious and influential UK and US incidents of the 20th century. To a large extent these have shaped the UK Environment Agency’s landfill development requirements and gas migration prevention guidance. That guidance was used until the advent of the EU Landfill Directive in the late 1990s, and has been carried forward subsequently.

Current landfill gas safety requirements are now embodied in the EU ATEX Directive (and UK’s DSEAR regulations).

More About the Abbeystead Disaster, Cumbria

The explosion at the Abbeystead valve house on 23rd of May 1984 killed 16 as a result of methane gas in the atmosphere:

The Abbeystead disaster occurred on the evening of 23 May 1984. That’s when a methane gas explosion destroyed a waterworks’ valve house at Abbeystead, Lancashire, England. A group of 44 visitors was inside the underground building at the time. They were attending a public presentation by North West Water Authority (NWWA) to demonstrate the operations of the station.

Eight were killed instantly by the explosion, and the others were severely injured.

The explosion also caused the concrete roof to fall down on to the group, destroying the steel mesh floor. And, throwing some of the victims into the water chambers below which rapidly filled with river water.

Another eight people subsequently died of their injuries in hospital.

An 11-year-old boy and his mother were among the dead. The official inquiry into the disaster concluded that the methane had seeped from coal deposits 3,937 feet (1,200 m) below ground and had built up in an empty pipeline.

The gas was then ejected into the valve house by the sudden pressure of water as the pumps were switched on.

The cause of ignition has never been determined.

The methane is thought to have been from natural sources rather than landfill gas. The accident provides a tragic example of the potential hazard posed by methane in tunnels and pumped water mains.

via Wikipedia

Read the BBC News report on the Abbeystead Disaster here.


The landfill gas explosion incidents follow:

Loscoe Explosion, Derbyshire

An explosion occurred in a bungalow adjacent to the landfill site at Loscoe during March 1986, when a large fall in barometric pressure occurred (29 millibars in 7 hours).

Loscoe Landfill Gas explosion UK

The explosion destroyed one bungalow. The resulting investigation showed two more houses had been unfit for habitation for the preceding nine months, and others for short periods.

Site History

The site was used as a brickworks from the mid-nineteenth century until the early 1970’s.

The quarry in which it was situated comprised an elliptical hole with three stepped quarry faces. The quarry was part-filled with inert waste products from the brick-making which ceased in 1971.

Permission was then granted for the tipping of inert materials only. From 1973 to 1975 a number of companies tipped at the site, until one firm acquired the sole rights, and in 1978 purchased the site.

During 1977 a licence had been granted to tip a wide variety of wastes, including 50 tons per day of untreated domestic waste.

The first signs of gas generation were in 1984. Lawns showed crack-lines of dead dried-grass, and trees began to wilt and die in the surrounding gardens.

Later the soil around the affected areas began to heat up. The initial heating effect is thought to be have been due to the presence of methane feeding bacteria.

From 1977 to 1982 amendments to the licence were granted to increase the quantities of domestic waste tipped. Extensions to landfilling were granted despite complaints from the residents of adjacent houses of vermin and flies.

Houses surrounded the site on all four sides, those on the fourth side were built in the 1970’s.

Action Taken Following the Explosion

After the explosion Derbyshire County Council monitored methane levels in the houses at regular intervals. Attempts were also made to draw the gas out of the tip by horizontal and vertical methane extraction wells. This proved only partially successful due to a perched water table (Open University literature 1989).

Flow rates of landfill gas generated from the site measured subsequently were 150-200 cubic metres of gas per hour, at a 30-35% methane content. 3-4% oxygen was present: or approximately 45-70 cubic metres of methane per hour.

After the explosion landfill gas extraction wells were installed and this landfill gas was extracted.

This was achieved using a grid of 17 wells, and the extracted gas was flared off through a purpose built pump and flaring unit.

Other Landfill Gas Explosions and Dangerous Incidences

North Yorkshire

A house 50m from a waste filled limestone quarry was seriously damaged by a methane gas explosion. The gas was generated from domestic and commercial waste dumped over a three year period. This had migrated along natural fissures in the limestone underneath the house.

Precautions had been taken against gas migration as the site was filled including facing the quarry wall with clay and creating rubble ‘chimneys’ within the waste. These chimneys and a permeable cover material had however become covered over in the final phase of operation.

There was no prior warning of the problem. But, for four days after the explosion high concentrations of methane were found in the drains of the area. Other houses in the vicinity were checked for methane, but only very low levels were recorded.

The remedial steps taken were to dig trenches into the waste along the rock faces and backfill these with imported rock, graded 75-250 mm.

Within two weeks of the trenches being excavated only trace levels of methane were recorded outside the site (County Surveyors Society, 1987).

Atlanta, Georgia, USA

In December, 1967 a single storey building was destroyed. Two people were killed and two injured by a methane gas explosion. The building had a basement which was bricked up. This sealed it except for a pipe which connected the basement to the rest of the building. Landfill gas escaping from the pipe was ignited, possibly by a cigarette, and an explosion occurred. (Parker.1987)

Winston-Salem, North Carolina, USA

In 1969 a gas explosion occurred in an armoury built close to a landfill site. The building had been erected seven years earlier when the landfill site was operational. But, about a week before the explosion extra material was deposited over the site.

It is thought this caused the gas migration into the building. The explosion killed three people, and twenty five were injured (Parker, 1987).

Conclusions

In all these accidents the landfill gas explosions were caused by alterations to the pathways for gas migration. This was done after capping, or after the closure of the site. These alterations or blockages caused the landfill gas to accumulate in an enclosed area, build-up and exceed the lower explosive gas-concentration limit.

Therefore, the problems associated with landfill gas both in the gaseous phase and dissolved in landfill leachate are a long term explosion risk.

Such risks may still cause landfill gas explosions, in the future, and therefore landfill gas explosion risks must be always be carefully assessed and managed. Throughout Europe, local regulations apply in compliance with the EU ATEX Directives. In England and Wales, they are known as the DSEAR (Dangerous Substances and Explosive Atmospheres Regulations).

We hope that you found this article on landfill gas explosions interesting. If you have knowledge of a similar incident, please add as many details as you can, to the comments below.

Steve Last of IPPTS Associates is an expert with considerable experience in carrying out DSEAR Risk Assessment for Landfill Sites.

Contact Steve for a quotation for your DSEAR Risk Assessment.



Related Landfill Gas Articles:

How About Trading Carbon when Landfill Gas is Recovered? Frequently Asked Questions in Carbon Trading How does the EU Emissions Trading Scheme the EU ETS - also referred to as CCTS and CDM affect the Waste Industry First of...

What if Landfill Gas Doesn\'t Explode but People Breath-In t Health Effects of Landfill and Landfill Gas The context for the Emissions and Health Impacts Associated with Waste Management report is a UK Government Strategy Unit Report commissioned to assess...

What Other Unpleasant Effects Does Landfill Gas Have? Landfill gas when emitted from a landfill gives rise to a list of possible impacts Just think of the following attributes of landfill gas emissions each of which brings the...


In a rush? Want to download this page as a pdf file, for future reference? If so, just tell us below, where to send it. This is a free service for all our readers.

steve@landfill-gas.com

Tags: , , , , ,

2 Responses to “Notorious Landfill Gas Explosions During the 1980s in the UK and the US”

  1. OzaSeptember 4, 2018 at 8:53 am #

    Good information but please consider updating this info. i could use some later case studies. Thanks.

  2. Jacqui TraskMarch 9, 2019 at 3:38 pm #

    That would wake you up!

Leave a Reply

This site uses Akismet to reduce spam. Learn how your comment data is processed.

Animated Social Media Icons by Acurax Wordpress Development Company
%d bloggers like this:
Visit Us On TwitterVisit Us On FacebookVisit Us On Google PlusVisit Us On PinterestVisit Us On YoutubeVisit Us On LinkedinCheck Our Feed